EVOLUTION POWERSPORTS 2020 MAVERICK X3 195 HP TURBO RR STOCK INJECTOR ECU PROGRAMMING

Description

2020 Maverick X3 195 HP TURBO RR Stock Injector ECU Programming by EVP: The 2020 Can Am X3 RR is so good that it deserved an enhanced dyno testing and field testing regimen to make sure our tuning is the best available anywhere. Tuning this beast started in Sturgis, SD in early August 2019 for some high altitude calibrations and testing while simultaneously remote tuning an identical X3 RR on one of our wheel dynos in Phoenix, AZ. This allowed us to make rapid development on early tuning files. Our 2020 RR was then brought back to our facility in Wisconsin where it was joined by a second development X3 XMR RR (aka the Green Machine).

We decided from now on all heavy tune development would be performed on our engine dyno rather than a wheel dyno. This change was made for two reasons. First, an engine dyno removes the CVT drive system from the tuning equation. The CVT will always try to keep the engine REVs at within a narrow RPM range during a power sweep whereas our engine dyno can sweep the entire operating range of the engine. Also, the engine dyno can hold RPM’s at very specific values which allows us to tune those areas, throttle openings and load levels without the “Continuously Variable Transmission” varying the load and RPM. Tuning the engine outside of the CVT allows us to deliver a more refined tune and eliminates all of the variables (tire size, clutching, strap tension, etc) which result in the incredible spectrum of dyno figures published for this vehicle. For example, the stated dyno numbers for a bone stock 2020 X3 RR among our shop and others varied by over 20 WHP! All vehicles were tested on the same manufacturer dyno. This is ridiculous. The factory rates the power of their engines at the crank and we do too.

You can see from our dyno graphs that the power curves are extremely flat – in fact our tunes make within 6 horsepower of peak power over a 1200 rpm range! This means that even if your clutching is 500 or more RPMs off, that your X3 will be sacrificing only a few ponies!Field testing the beta stock injector, stock turbo tunes was started in St Anthony, ID. Conditions could not have been worse for a SXS. 93 Degrees F and 5500′ elevation created a density altitude of 9300′. Once we proved the tunes there, we then drove straight to Glamis, CA and did the worst torture testing we have ever done on any vehicle previously. First we filled up our X3 with poor California 91 Octane fuel. With ambient temperatures at 110 Deg F, we ran each tune on both Oldsmobile and at the sand drags over and over again. We are confident our tuning is the most thoroughly tested in the industry.Evolution Powersports works with top racers in the industry such Marc Burnett, Dustin Jones, Kyle Chaney, Matt Burroughs, Lonestar Racing, Elliot Burns, Casey Scherer, Jason Watt, Scottie Lawrence and many others. 6 out of the top 10 drivers in the Lucas Oil Midwest series used EVP tunes & products to help get them to the podium. EVP programming and products are also used by top drivers in GNCC, BITD and SCORE race series with countless podiums. Our tunes are the most powerful, refined and safest tunes on the market. Also, EVP owns 6 development Can AM X3’s. This allows us to do parallel development on stock turbo, consumer tunes while engineering next level products and tunes.

Tune Features:
Revised intercooler fan settings – makes the OEM intercooler far more effective!
Left foot braking enabled for 2 foot operation
Improved boost response / low to midrange power improvements
Launch button for drag racing available – Our on/off switch replaces the OEM override switch which allows Launch Start from a standstill and prevents “low gear” mode. This allows operation of the gas pedal and brake pedal at the same time from a standstill to launch the car HARD!
Speed limits raised / TQ limits removed in Low & High Gear
Low & High Gear rev limit increased from 8300 to 9000 RPMS
V-Max Raised
Improved throttle response in all modes (E-Gas Settings Improved) – Linear throttle rather than the lazy pedal the factory has programmed
Fans set to activate at 165 degrees
Race Start – No need to press the brake to start vehicle
Fueling is corrected for the various stages so no fuel controllers are needed